gas condensing boiler with advanced technology

Fangkuai Group has more than 60 independent intellectual property rights, advanced clean fuel condensing boiler with advanced technology manufacturing technology, and jointly established a clean fuel boiler production, research and research cooperation base with Tsinghua University and Xi'an Jiaotong University. An enterprise with a R & D and test center for clean fuel boilers. The thermal efficiency of “Fangkuai” boilers can reach 107%, which has been included in the national special equipment energy-saving catalog. The company developed ultra-low nitrogen full premixed combustion condensing boilers and ultra low nitrogen emission fuel gas boilers, which are developed by the company using Ultran condensation technology.

How to improve the thermal oil condensing boiler with advanced technology efficiency oil boiler thermal efficiency is a lot of users are taken into account, we believe that this issue is the direction of each used in the production of various types of oil boiler manufacturers have been in the study. Many users at the time of the oil furnace to operate, often in the actual production process, we found some new problems, but all the problems, the headache is higher oil boiler flue gas temperature, low thermal efficiency the phenomenon that a serious impact on our work, then how should we do to improve the thermal efficiency of it? need to understand this is to meet the low-temperature characteristics of the thermal oil comes as synthetic heat transfer oil. However, the vast majority of synthetic HTF complex biphenyls, benzene derivatives of both components, or a vapor of volatiles has strong carcinogenicity, it is strongly recommended to select customers conducting oil mineral oil products. Second, conducting oil products to meet the low temperature performance process, but also have a relatively high flash point required. In general, oil engineers suggest, low flash point not lower than the HTF opening 200 ℃. After a professional manufacturer of continuous research and improvement of its equipment, in order to improve its thermal efficiency was found to be increased oil boiler heating surface of the tail, say, air preheater and economizer. But when organic heat carrier furnace return temperature is high, you can not set the economizer, air preheater can only be set to alleviate the situation. So if the oil boiler and not other low-temperature heating system heat exchanger, then the only way to improve energy efficiency is adding air preheater. After adding air preheater can be a corresponding increase in the flow rate of heat-conducting oil, oil boiler in order to ensure safe, reliable and stable work, the thermal efficiency of the boiler plant with thermal oil will be a corresponding increase.

Gas condensing boiler with advanced technology safe handling as the country increasingly stringent emission standards for air pollution, the country has already started work boilers from coal to gas, out of heavily polluting coal-fired boilers, gas boilers using clean fuels. In this regard, Kono Tips boiler, gas boiler process, the need to pay attention to some safety issues: 1. burner to keep the working environment clean and dry, burner cleaning and maintenance once per shift to the control circuit must not get wet, affected by high temperature. 2. Check the electrical installations, mainly: whether the damaged wire, jacket damage, without loosening the screws, the contact is good, the motor is running any abnormal sound. 3. During normal operation, the burner portion close to thermodynamic device (such as a flange connection part) will be very hot, to avoid burns. Do not place near flammable materials, so as not to cause a fire. 4. combustor during startup, if the burner is locked repeated alarm reasons should be identified, and then identify failures and excluded press the reset button (pressing the reset button must not exceed 10 seconds), continue to start. 5. After the total gas pipeline experienced a temporary power failure solenoid valve (steel tile shed) to stop gas supply will automatically shut down until the first call burner electric alarm device to send, then a small hammer solenoid valve with total on hand to pull, you must first send electricity to manually open solenoid valve, solenoid valve will be closed and vice versa total. 6. fireman not mess-tune the burner, abnormal promptly notify management personnel, approved by management and then make adjustments. 7. In the long-term shutdown state, to do maintenance work on the boiler equipment, for each transmission parts to clean, lubricate.

Primary air tube blockage is what causes? How to prevent? Reason: 1) blocked or coked-burner fire nozzle inlet is blocked portion of small oil gun and other debris. 2) too many impurities coal, powder machine speed is too high, the pulverized coal and primary air speed too low. 3) powder machine speed is too high, too much under the powder without timely blown away. 4) a low pressure (throttle open or not to open too small), can not take away meal. Precautions: 1) to the powder and the rotational speed of the unit load and adjust relevant primary pressure according to the powder not more than 700 rpm rotation speed, a wind speed of each holding 25 ~ 30m / s, the mixed primary air temperature was controlled at 180 to 250 ℃, a pressure depending on the load, depending on coal, in the range 2.5 ~ 3.8kPa. 2) find a wind speed is too low, the primary air temperature is lower than the normal value should be to lower the rotation speed corresponding to the normal to the powder of a primary air temperature and wind speed. 3) open, gas steam condensing boiler with advanced technology tank should be fully cut-off torch powder, the powder in the tube is blown accumulated powder. 4) Fire mouth clogged or coked should try to remove. What causes large vibrations induced draft fan? 1) motor bearings in oil, resulting in large vibration and bearing wear; 2) even when the shaft is mounted on the center not good; 3) induced draft fan stall surge; 4) anchor bolt loosening induced draft fan; 5) blade fouling or wear ,lost balance.

Industry Heating technology, Gas condensing boile and

WALL MOUNTED OIL CONDENSING BOILER Advanced condensing technology for detached houses and apartment buildings. The compact COB wall mounted oil condensing boiler is equipped with a two-stage burner, i.e. it combines robust technology with high efficiency. You can operate it with low sulphur fuel oil or bio-oil (B10).

Learn More

Boilers in Wayne NJ - airtempserviceco.com

Fuel: Gas-Fired (Natural or LP) Input: 40 to 199 MBH. Output: 37 to 184 MBH. Venting: Sealed Combustion, Direct Vent. Trim: Water. Combustion: Direct Spark. 90% AFUEENERGY STAR® Efficient! Gas-fired Condensing Boiler for Natural or LP Gas; Cast Iron Sections with Steel Push Nipple Connectors; Advanced Digital Control Board Technology

Learn More

AERCO Introduces Most Advanced Commercial Condensing Boiler

Jan 30, 2017 · Benchmark® Platinum Delivers Unprecedented Levels of Efficiency, Reliability and Reduced Operating Expenses for Greater ROI Blauvelt, NY January 30, 2017 Twenty years after introducing the Benchmark series of high efficiency, condensing boilers, AERCO launches the Benchmark ® Platinum, their most advanced commercial condensingboiler yet.

Learn More

GAS CONDENSING TECHNOLOGY: KEY FOR EFFICIENCY AND CLEAN AIR

prove air quality. Gas condensing boilers, the advanced technology described in this brochure, help to achieve these policy goals. Why? Firstly, because these boilers allow to use natural gas instead of coal. This is important, because gas usage significantly reduces the emissions of air pollutants and CO 2, compared to coal.

Learn More

Oil condensing technology - Vitoladens / Vitorondens

condensing technology Condensing technology utilises not only heat from the combustion of fuel oil or gas, but also heat that escapes unused with conventional heating technology. Condensing boilers extract almost all of the heat in flue gases and convert it into additional heating energy. To do this, Viessmann condensing boilers

Learn More

Condensing Boilers | AERCO

An industry leader in water heating design for 65 years, AERCO was the first to introduce commercial condensing, fully modulating boilers. We continue to improve upon our innovative technologies and advanced designs.

Learn More

Commercial Gas Boilers | Viessmann

Advanced gas condensing boiler An award winning boiler with an output range of 80 - 318 kW, or 636 kW as a twin unit. Features advanced condensing technology, making it an economical boiler suitable for many different applications.

Learn More

Oil/gas boilers and low pressure hot

Gas condensing boiler with MatriX cylinder burner, 400 to 620 kW Vitocrossal 100 Type CI Gas condensing boiler with MatriX cylinder burner, 80 to 318 kW (Twin cascade up to 636 kW) Advanced condensing technology makes the Vitocrossal an economical condensing boiler that is suitable for many different applications. VITOCROSSAL 200 CRU/CM2/CM2C

Learn More

What is a Condensing Gas Boiler? | U.S. Boiler Company

Traditional vs. Condensing Gas Boilers. Traditional gas boilers burn natural gas or propane to heat the water in a home heating system. These boilers are vented to the outside via a chimney flue or vent pipe. Traditional boilers typically operate at higher temperatures, which means that a portion of heat is vented to the outside during the

Learn More

New technology will allow gas boilers to think | Gas Boilers

Baxi has developed advanced technology «Think intelligence inside. With this newest system boilers will think! New lines of gas boilers Luna Platinum and Luna Duo-tec MP were developed on basis of this technology.

Learn More

#settings.esLogo# Most Efficient 2016 &##8212; Boilers

Buderus GB142 Series Buderus GB142 Condensing Gas Boiler: Utilizing advanced condensing technology with an AFUE of 95%, the Buderus GB142 Wall-Mounted Condensing Boiler maximizes the heating value of every cubic foot of natural gas or liquid propane.

Learn More

10 Best Boilers of 2019 - Gas, Oil, Propane, Electric

Non-condensing vs condensing systems. Condensing technology is used in high-efficiency boilers with an AFUE of 90% or above. Boilers with these systems condense the water vapor in the flue gases to recover heat that would otherwise be lost from a non-condensing system when the gases exit the house.

Learn More

Gas condensing technology - Vitodens / Vitocrossal

advanced gas condensing technology from Viessmann How condensing technology works: Viessmann gas boilers and condensing technology turn up to 98 percent of the energy spent into heat. Through the condensation of water vapour contained in flue gas, additional heat is released which is returned to the heating system. This

Learn More

HTP - Elite Ultra Condensing Boiler

The Elite Ultra Highly Efficient Condensing Boiler & Combi comes equipped with HTP Link technology, a WiFi solution that enables remote monitoring of the appliance and its system. Proper personnel of your choice will be sent a text message or e-mail alert when faults or other key activities occur in the boiler, allowing you peace of mind even

Learn More

Boilers - Flow Underfloor and Central Heating

The whisper quiet Grant condensing unit boiler is an indoor, ultra high efficiency, floor standing heat generator for domestic heating and hot water production. Advanced condensing flue combustion technology scavenges energy found in the flue gas that would otherwise be lost to the atmosphere resulting in running efficiencies up to 97%.

Learn More

Leave your email

We will contact you in the first time and choose the right boiler model for you and provide a reasonable solution.