water tube boiler and fire tube boilers

Comfortable life of people is inseparable from the northern winter heating water tube boiler and fire tube boilers, normal, stable heat source is vital to people's lives. But the attendant is an increasingly serious environmental pollution problems, the implementation of coal to gas policy without delay, using the gas hot water boiler is the general trend. In order to achieve green heating, the National Tourism Administration Service Center decided to phase out the existing coal-fired boilers, the introduction of clean and environmentally friendly gas hot water boiler. Fast boiler with their own strong comprehensive strength and rich experience in the heating industry cooperation gained the trust of the National Tourism Administration Service Center, and ultimately provide a vacuum hot water boiler (T6-2800 2 sets of 2.8MW by fast Boiler ).

Third, the correct way to use

If the boiler house, without the use of long-term need for maintenance, deactivation can be taken within a month of wet maintenance of law, but more than a month to dry maintenance method. Many gas boiler maintenance of the law, but also a lot of caveats, though it itself does not pose any safety problems, but the wrong use may also cause a lot of problems. So no matter what method the consumer, as long as the full attention and follow the steps, they allow us to more long-term use of the boiler.

SUMMARY major maintenance system 1 gas water tube boiler and fire tube boilers, burner maintenance: cleaning gas Burner full turn cup, ignition means, filter, pump, motor and impeller systems, the lubricant added to the throttle linkage arrangement. Re-awarded for combustion testing. 2, the controller Maintenance: Maintenance detecting electrical components, control lines, the control box clean ash collection, each control point is detected. Finally sealed. Controller element to prevent the moisture. 3, water supply system maintenance: repair water treatment plant to check whether water quality standards, a comprehensive clean-water treatment system, to check the functioning of the pump and lift, check that each pipe valves can be used flexibly and so on. Water and electricity, the system closes the valve after each filled with water. 4, furnace maintenance: In order to make the boiler safe and economic operation lasting, must in daily use, strengthen the maintenance of the boiler. This is also to prevent lower thermal efficiency, an important measure to avoid the use of state of deterioration and boiler accident.

Big factor in gas water tube boiler and fire tube boilers gas consumption has two aspects, one large boiler load; the second is the low thermal efficiency of the boiler. To reduce its gas consumption on these two aspects, specifically as follows.

1 in load factors. Under the premise of not measuring instruments, we are in accordance with the conventional wisdom used to measure the heat output. When the user needs to boiler unstable, increase the amount of heat boiler, also will increase the load. And because no measurement instruments, so people will mistakenly believe that gas consumption is increased.

2, the thermal efficiency decreases. About thermal efficiency drops There are many factors that we want to include several commonly encountered, we can control their own boiler equipment to be checked.

Water-tube boiler - Wikipedia

A high pressure watertube boiler (also spelled water-tube and water tube) is a type of boiler in which water circulates in tubes heated externally by the fire. Fuel is burned inside the furnace, creating hot gas which heats water in the steam-generating tubes.

Learn More

Firetube vs Watertube Boilers: a Comparison

The firetube boiler passes combustion gas inside a series of tubes surrounded by water in a vessel to produce steam, while a watertube instead sends water through a series of tubes surrounded by combustion gas used to transfer heat energy and produce steam.

Learn More

Water Tube Boiler Parts and Functions - Boilersinfo

In the water tube boiler, the water and steam flow inside the tubes and the hot gases flow over the outside surfaces. Where as in fire tube boilers hot gases from combustion travels through the tubes. flue gases produced from furnace where fuel is burnt. Water tube boiler design and working

Learn More

Water Tube Boiler Working Principle, Types of Water Tube

A water tube boiler can be defined as a Steam boiler in which the flow of water in the tubes, as well as hot gases, enclose the tubes. Not like fire tube boilers, this boiler attains high-pressures, as well as high-steam capabilities, can be achieved. This is because of condensed tangential pressure on tubes which is known as hoop stress.

Learn More

What is difference between water tube boiler and fire tube

May 05, 2017 · water tube boiler are that boilers in which water is inside the tubes. while fire tube has fire or smoke inside the tubes and water is surrounded by them. Read Water tube boiler and Fire Tube Boiler in details.

Learn More

Water Tube Boiler | Operation and Types of Water Tube Boiler

Aug 22, 2018 · A water tube boiler is such kind of boiler where the water is heated inside tubes and the hot gasses surround them. This is the basic definition of water tube boiler. Actually this boiler is just opposite of fire tube boiler where hot gasses are passed through tubes which are

Learn More

Difference between Fire Tube Boiler and Water Tube Boiler

Mar 19, 2016 · One is known as fire tube boiler and the other one is known as water tube boiler. These boilers is largely used in power development and other industrial like sugar industries, cotton industries etc. for steam generation.

Learn More

Difference Between Fire Tube Boiler And Water Tube Boiler--

The water in the tubes creates steam directly, instead of tubes heating water as is the case in a fire tube boiler. Water tube boilers are used more for industrial applications and less for heating purposes. A fire tube boiler transfers heat through tubes via thermal conduction, which then heats the water in the container and formulates steam.

Learn More

Water Tube Boiler | Operation and Types of Water Tube Boiler

Aug 22, 2018 · A water tube boiler is such kind of boiler where the water is heated inside tubes and the hot gasses surround them. This is the basic definition of water tube boiler. Actually this boiler is just opposite of fire tube boiler where hot gasses are passed through tubes which are

Learn More

A comparison between water tube and fire tube boilers

Fire tube boilers are a lower cost alternative to water tube boilers and are often used for smaller industrial facilities with lower operating pressures. The main advantages of a fire tube boiler are its simple construction, compact size and the ability to easily meet rapid fluctuations in steam demand.

Learn More

A comparison between water tube and fire tube boilers

Fire tube boilers In a fire tube or shell boiler, the hot combustion gases produced by the burner are passed through small tubes arranged in a pressurised cylindrical drum and surrounded by water. Heat energy is transferred to the water which is heated up until it becomes steam.

Learn More

Fire Tube Boiler Working Principle, Types of Fire Tube Boilers

Fire Tube Boiler Construction and Working Principle of Fire Tube Boiler. The construction of a water tube boiler can be equipped with cylindrical shell, vertical, firebox in the base, space for water in the center segment, and space for steam in the higher segment. A fire-grate is located at the fire-box base as well as coal is fired-up on the firebox.

Learn More

Types of boilers, Fire tube, water tube and combination

In a fire tube boiler, hot gas passes through the pipes and boiler feed water is inside the shell to be converted into steam. Fire tube boilers are usually used for relatively small steam capacities with low to moderate steam pressures.

Learn More

Water Tube Boiler And Fire Tube Boiler(Difference) - YouTube

Jul 05, 2016 · Water Tube Boiler And Fire Tube Boiler(Difference) LEARN AND GROW 119,650 views. Top 50 Steam Boilers Mechanical interview questions and answers for fresher experienced - Duration:

Learn More

4 Different Designs of the Fire Tube Boiler: Which Is Best

Dec 02, 2016 · Fire tube boilers are designed to transfer hot gases from the heating source and cycle these gases through tubes that circulate through a drum filled with water. This process effectively transfers the heat from the gas into the water, which effectively generates steam.

Learn More

Leave your email

We will contact you in the first time and choose the right boiler model for you and provide a reasonable solution.